您好!欢迎来访东营市兴达土方工程有限公司!关于我们 | 联系我们 | 在线留言
服务热线
18678687777(来经理)
联系我们
联系人:来经理
联系电话:13793968666
地址:山东省东营市广饶县
新闻中心

长臂挖掘机出租保持液压系统清洁的3个方法!

日期:2021-03-19   来源:http://www.dybocheng.com
长臂挖掘机的是近几年来流行一种挖掘机 它可以增加18-30米不同长臂,为日常使用提供的方便,下面就由加长臂挖掘机出租的小编来为大家讲解一下挖掘机的液压系统清洁的3种技巧:
The long arm excavator is a popular excavator in recent years. It can increase different long arms of 18-30 meters, which provides convenience for daily use. The following is a brief introduction to the three cleaning skills of the hydraulic system of the excavator by the rental editor of the long arm excavator
(1)定期更换液压油。过滤性能良好的液压油含有多种添加剂,可防止机油在挖掘机维护过程中变质。然而,这些添加剂会在一段时间后失效。因此,油应该定期更换,以确保添加剂发挥作用。滤清器只能从机油中吸收有限的灰尘颗粒和其他杂质。
(1) Change the hydraulic oil regularly. The hydraulic oil with good filtration performance contains a variety of additives, which can prevent the deterioration of oil in the process of excavator maintenance. However, these additives will fail after a period of time. Therefore, the oil should be changed regularly to ensure that the additive works. The filter can only absorb limited dust particles and other impurities from the oil.

日立ZX系列(中型)机器每1000个工作小时更换一次液压油箱回油滤清器。更换液压油时,清洁液压油箱的吸油过滤器,以保持系统清洁。更换液压油滤清器时,请检查滤清器底部是否有金属颗粒或碎屑;如果有铜或铁屑,液压泵、液压马达或阀门可能会损坏或将会损坏;如果有橡胶,则液压缸密封件损坏。
Hitachi ZX series (medium) machines change the return oil filter of hydraulic oil tank every 1000 working hours. When changing the hydraulic oil, clean the oil suction filter of the hydraulic oil tank to keep the system clean. When replacing the hydraulic oil filter, please check whether there are metal particles or debris at the bottom of the filter; if there are copper or iron debris, the hydraulic pump, hydraulic motor or valve may be damaged or will be damaged; if there is rubber, the seal of the hydraulic cylinder will be damaged.
(2)定期排放油箱内的污物,定期向油箱内排放水和沉淀物。油中的杂质很重要,但在整个液压系统中定期更换液压油也很重要。这是彻底有害杂质(如系统杂质和氧化液压油)的可靠方法。然后再次向液压系统中添加日立的清洁液压油。请每250个工作小时排空一次油箱。
(2) Regularly discharge the dirt in the oil tank, and regularly discharge water and sediment into the oil tank. It is important to remove the impurities in the oil, but it is also important to change the hydraulic oil regularly in the whole hydraulic system. This is the only reliable way to thoroughly remove harmful impurities (such as system impurities and oxidized hydraulic oil). Then add clean hydraulic oil recommended by Hitachi to the hydraulic system again. Please empty the tank every 250 working hours.
(3)如果液压油被污染,特别是当泵或油缸和马达损坏时,必须更换并清洗所有液压油。向油箱添加液压油或读取液压油时,保持液压挖掘机的工作区域清洁,并确保滤清器箱盖周围的区域清洁。仅使用干净的漏斗或容器。请勿将灰尘带入系统。维护液压系统时,只能使用干净的塑料塞来密封管道末端。维护液压部件时,工作台必须干净。检查工具的使用,它们也应该很干净。
(3) If the hydraulic oil is contaminated, especially when the pump or cylinder and motor are damaged, all hydraulic oil must be replaced and cleaned. When adding hydraulic oil to the tank or reading hydraulic oil, keep the working area of the hydraulic excavator clean and ensure that the area around the filter box cover is clean. Use only clean funnels or containers. Do not bring dust into the system. When maintaining the hydraulic system, only use clean plastic plugs to seal the end of the pipe. When maintaining hydraulic components, the worktable must be absolutely clean. Check the use of tools, they should also be clean.


【本站图片均由网站所有方提供,部分图片来源于网络,如无意中侵犯了某媒体或个人的知识产权,请来信或来电告之,本网站将立即删除。】