长臂挖掘机

省时 省力 省财富

长臂挖掘机长期存放前，需对机器周身进行检查和保养。清除机身上沾染的泥土，对机器各部件进行润滑，检查润滑油并确定其在适当的油位，以免受到污染。还有什么要注意的呢？下面长臂挖掘机租赁厂家为您解说。

Before the long-arm excavator is stored for a long time, it is necessary to inspect and maintain the whole machine. Clean the dirt on the machine body, lubricate all parts of the machine, check the lubricating oil and make sure it is at the proper level to avoid contamination. What else should we pay attention to? Next, the leasing manufacturer of long-arm excavator will explain to you.

1、油箱满油柴油机，防止柴油机箱内腔锈蚀。

1. The oil tank is full of diesel engine to prevent the internal cavity of the diesel box from rusting.

2、将挖机的汽柴油操纵杆放置待速部位，各操作手柄放置空挡部位。

2. Place the diesel and gasoline control levers of the excavator at the waiting position, and the operating handles at the neutral position.

3、长臂挖掘机发动机运行以后要暖机，随后反复地做走动、转动及其发掘姿势便于润化全部的、构件。

3. The engine of the long-arm excavator should be warmed up after running, and then repeatedly walk, rotate and excavate the position to moisten all the components.

4、释放挖机发动机内的冷冻液；拆换发动机油，长期放置挖机的情况下，旧挖机机油非常容易浸蚀挖机发动机的金属材料零件。

4. Release the refrigerant in the excavator engine; When the engine oil is replaced and the excavator is placed for a long time, the old excavator oil is very easy to corrode the metal parts of the excavator engine.

5、挖机放置于户外时，一定要查验、清除挖机内的贵重的物品，需时，再改装两把自身的锁，避免物件遗失失窃。

5. When the excavator is placed outdoors, it is necessary to check and remove the valuables in the excavator, and if necessary, modify two locks of its own to avoid loss and theft of objects.

6、挖机长期性储放前，需对设备全身开展定期检查维护保养。消除整体机身上染上的土壤，对设备各构件开展润化，查验润滑脂并确认其在恰当的油量，以防遭受环境污染。

6. Before the excavator is stored for a long time, it is necessary to carry out regular inspection and maintenance for the whole body of the equipment. Eliminate the soil on the whole body, moisten the components of the equipment, check the lubricating grease and confirm that it is in the proper amount of oil to prevent environmental pollution.

7、长臂挖掘机应选用牢靠平整的路面放置，履带式前后左右应垫上木料，尽量减少湿冷、盐土、多灰尘等恶劣的环境。液压缸取回，液压缸处在大腔情况。有标准得话，找几片面料将曝露在外面的液压缸开展遮住。

7. The long-arm excavator shall be placed on a firm and flat road surface, and the crawler excavator shall be padded with wood at the front and rear, so as to minimize the harsh environment such as damp, cold, saline soil, and dust. The hydraulic cylinder is taken back, and the hydraulic cylinder is in large chamber. If there is a standard, find a few pieces of fabric to cover the exposed hydraulic cylinder.

8、蓄电池在严寒的条件下非常容易馈电，假如情况可以得话拆下来蓄电池放进房间内开展储放。拆蓄电池时，先要断开负级线，随后再断开正级线；组装时要先衔接正级线，再衔接负级线。因工程机械设备电气控制系统全是负级搭铁，那样做是为了避免拆卸蓄电池时导致短路故障。

8. The battery is very easy to feed in severe cold conditions. If possible, remove the battery and put it in the room for storage. When removing the battery, first disconnect the negative line, and then disconnect the positive line; During assembly, connect the positive line first, and then connect the negative line. Because the electrical control system of construction machinery and equipment is all grounded at negative level, that is to avoid short circuit fault when removing the battery.

9、如挖机储放的时间太长，零件上因并没有非常的挖机机油造成锈蚀，下一次实际操作设备就有可能出现异常的损坏，因此每月应起动一次挖机发动机，运行后应查验挖机机油位、机油位、齿轮油位，主题活动一次润化构件，与此同时为蓄电池充电。

9. If the excavator has been stored for too long, the parts will be rusted due to the lack of special excavator oil, and the equipment may be damaged abnormally in the next actual operation. Therefore, the excavator engine should be started once a month. After operation, the excavator oil level, engine oil level and gear oil level should be checked. The theme activity is to moisten the components once and charge the battery at the same time.

所以，挖掘机闲置很长时间，要做好保管工作，这样才能让挖机再次启动时不出任何问题。更多相关事项就来我们网站http://www.dybocheng.com咨询吧！

Therefore, the excavator has been idle for a long time, so it should be well kept so that there will be no problems when the excavator is started again. Come to our website for more relevant matters http://www.dybocheng.com Ask!