您好!欢迎来访东营市兴达土方工程有限公司!关于我们 | 联系我们 | 在线留言
服务热线
18678687777(来经理)
联系我们
联系人:来经理
联系电话:13793968666
地址:山东省东营市广饶县
租赁动态

长臂挖掘机施工时需要做正确的操作

日期:2022-07-25   来源:http://www.dybocheng.com
作用液压挖掘机进行吊装操作进,应确认吊装现场周围状况,使用高强度的吊勾和钢丝绳,吊装时要尽量使用专用的吊装装置;作业方式应选择微操作模式,动作要缓慢平衡;吊绳长短适当,过长会使吊物摆动较大而难以精确控制;要正确调整铲斗位置来防止钢线绳滑脱;施工人员尽量不要靠近吊装物来防止因操作不当发生危险。
When using hydraulic excavator for lifting operation, confirm the surrounding conditions of the lifting site, use high-strength lifting hooks and wire ropes, and try to use special lifting devices during lifting; The operation mode should be micro operation mode, and the action should be slow and balanced; The length of the lifting rope is appropriate, and too long will make the lifting object swing larger and difficult to control accurately; Correctly adjust the bucket position to prevent the steel wire rope from slipping; The construction personnel should try not to get close to the hoisted objects to prevent danger due to improper operation.
作业时,机器的稳定性不仅能提高工作效率,延长机器寿命,而且能确保操作;驱动链轮在后侧比在前侧的稳定性好,且能够防止终传动遭受外力撞击;履带在地面上的轴距总是大于轮距,所以朝前工作稳定性好,要尽量避免侧向操作。
During operation, the stability of the machine can not only improve the working efficiency and prolong the service life of the machine, but also ensure the safety of operation; The stability of the drive sprocket at the rear side is better than that at the front side, and it can prevent the final drive from being impacted by external forces; The wheelbase of the crawler on the ground is always greater than the wheelbase, so the stability of working forward is good, and lateral operation should be avoided as far as possible.
要保持挖掘点靠近机器,以提高稳定性和挖掘机;假如挖掘点远离机器,造成因前移,作业就不稳定;侧向挖掘比正向挖掘稳定性差,长臂挖掘机如果挖掘点远离机体,机器会更加不稳定,所以挖掘点与机体应保持合适的距离,以使操作平衡、的。
Keep the excavation point close to the machine to improve the stability and excavator; If the excavation point is far away from the machine, the operation will be unstable due to the forward movement of the center of gravity; The stability of side excavation is worse than that of forward excavation. If the excavation point of long arm excavator is far away from the center of the machine body, the machine will be more unstable, so the excavation point and the center of the machine body should be kept at a proper distance to make the operation balanced and efficient.
长臂挖掘机
长臂挖掘机厂家建议您在挖掘机作业时,除松散土壤外,其上限开挖高度和深度,不应超过机械本身性能规定。反铲作业时,履带距工作面边缘距离应大于2.0m。
The manufacturer of long arm excavator suggests that the upper limit excavation height and depth should not exceed the performance requirements of the machine itself, except for loose soil. During backhoe operation, the distance between the crawler and the edge of the working face shall be greater than 2.0m.
挖掘机在作业前检查项目:照明、信号及报警装置等齐全有效;燃油、润滑油、液压油符合规定;各铰接部分连接可靠;液压系统无泄露现象。保证上述条件都具备才能开始工作。
Key inspection items of excavator before operation: lighting, signal and alarm devices are complete and effective; Fuel oil, lubricating oil and hydraulic oil meet the requirements; All hinged parts are connected reliably; The hydraulic system has no leakage. Ensure that the above conditions are met before starting work.
挖掘机要注意保持油箱内油液的清洁。不然可能会因为夏天温度比较高,出现故障,从而影响长臂挖掘机的使用寿命。
The excavator should pay attention to keeping the oil in the oil tank clean. Otherwise, there may be failures due to the high temperature in summer, which will affect the service life of the long arm excavator.
请各位用户悉知并遵守操作规程及注意事项,因为这不光关系到我们使用之后所呈现出的性能和效率,更对我们的使用有很大的帮助作用,希望各位能够认真的阅读一下,如果还有问题就来关注我们网站http://www.dybocheng.com做进一步的咨询。
Please know and abide by the operating procedures and precautions, because this is not only related to our performance and efficiency after use, but also very helpful to our use safety. I hope you can read it carefully and pay attention to our website if you have any questions http://www.dybocheng.com For further consultation.


【本站图片均由网站所有方提供,部分图片来源于网络,如无意中侵犯了某媒体或个人的知识产权,请来信或来电告之,本网站将立即删除。】